Product ID:ENAMEL SEMI-GLOSS RUST INHIBITING 24084 OD
MSDS Date:04/13/1992
FSC:8010
NIIN:00-290-6648
MSDS Number: BSHJT

CON-LUX COATINGS INC

226 TALMADGE RD
EDISON, NJ 08818-0847
US

Emergency Phone: 908-287-4000

Info Phone: 908-287-4000 / FAX 908-287-9288

Cage: 60189

CON-LUX COATINGS INC

847 EDISON, NJ 08818-0847 US

Telephone: 732-287-4000

Cage: 60189

ZINC OXIDE (AS NUISANCE DUST) (VAPOR PRESSURE 0.00 MM HG @

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 4%

ACGIH TLV: 10 MG/M3

LEAD CHROMATE (SARA 313) (CARCINOGEN) (VAPOR PRESSURE 0.00

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 15%

OSHA PEL .05PB.1CRO3(C)MG/M3

CARBON BLACK (VAPOR PRESSURE 0.00 MM HG @ 20C)

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: >1%

ACGIH TLV: 3.5 MG/M3

ISOPROPYL ALCOHOL (SARA III) (VAPOR PRESSURE 44.00 MM HG @

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 4%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

MINERAL SPIRITS (VAPOR PRESSURE 2.00 MM HG @ 20C) (LEL 1.0)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: >1%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

LEAD ORTHO-PLUMBATE (VAPOR PRESSURE 0.00 MM HG @ 20C)

CAS: 1314-41-6

RTECS: OG5425000

Fraction By Weight: >1%

OSHA PEL 0.05 MG/M3 AS PB

MAGNESIUM SILICATE (AS NUISANCE DUST) (VAPOR PRESSURE 0.00

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: >1%

OSHA PEL 20 MPPCF

ACGIH TLV: 2 MG/M3

TOLUENE (SARA III) (VAPOR PRESSURE 22 MM HG @ 20C) (LEL

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 1%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES AND SKIN MAY
OCCUR WITH OVEREXPOSURE. CONTINUED BREATHING OF VAPORS MAY IRRITATE
RESPIRATORY TRACT CAUSING HEADACHE, NAUSEA AND DIZZINESS.
CHRONIC: REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM
DAMAGE.
Explanation of Carcinogenicity:LEAD CHROMATE

First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE RESP IF NEEDED. TREAT
SYMPTOMS. EYE: FLUSH IMMED W/WATER 15 MIN MINIMUM. SEE DR. DERMAL:
WASH W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING. CONSULT DR IF
IRRITATION PERSISTS. INGEST: DRINK 1-2 GLASSES WATER TO DILUTE.
INDUCE VOMITING. IF SPONTANEOUS VOMITING OCCURS KEEP HEAD AT/BELOW
KNEE LEVEL TO PREVENT ASPIRATION INTO LUNGS. SEE DR OR POISON
CONTROL CTR IMMED

Flash Point Method:TCC
Flash Point:80.0F,26.7C
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER MIST
Fire Fighting Procedures:SMOTHER FLAMES WITH ONE OF THE ABOVE
EXTINGUISHING MEDIA. WATER MAY BE USED TO COOL DOWN UNOPENED
CONTAINERS IN VICINITY.
Unusual Fire/Explosion Hazard:CONTAINS FLAMMABLE SOLVENT. DO NOT USE IN
AREAS WHERE SPARKS OR OPEN FLAMES ARE PRESENT.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. WEAR
APPROPRIATE PERSONAL PROTECTION EQUIPMENT AND APPROVED RESPIRATOR.
PREVENT MATERIAL FROM CONTACTING ANY WATER SOURCES OR SEWERS
LEADING TO SURFACE WATERS.

Handling and Storage Precautions:STORE IN AREAS DESIGNED TO COMPLY
W/ANSI/NFPA 30 FLAMMABLE & COMBUSTIBLE LIQ CODE. GROUND CONTAINERS
WHEN POURING LIQ & POWDERS TO AVOID STATIC CHARGE
Other Precautions:DO NOT HANDLE UNTIL MANUFACTURERS SAFETY PRECAUTIONS
HAVE BEEN READ AND UNDERSTOOD. PROVIDE ADEQUATE VENTILATION OR
RESPIRATORY PROTECTION TO REMOVE DECOMPOSITION PRODUCTS DURING
WELDING OR FLAME CUTT ING COATED SURFACES.

Respiratory Protection:IN OUTDOOR OR OPEN AREAS, WHERE SUFFICIENT VENT
DETERMINED TO EXIST, A RESPIRATOR IS GENERALLY NOT REQUIRED. IN
RESTRICTED VENT, A NIOSH/MSHA ORGANIC VAPOR RESPIRATOR RECOMMENDED.
DURING SPRAY APPLIC, ORGANIC VAPOR & SPRAY MIST RESPIRATOR.
Ventilation:IN CONFINED SPACES MECHANICAL VENTILATION IS REQUIRED TO
KEEP THE AIR CONTAMINANT CONCENTRATION BELOW TLV/PEL.
Protective Gloves:IMPERVIOUS TYPE FOR REPEATED/PROLONGED
Eye Protection:SAFETY EYE WEAR (PROTECT AGAINST SPLASH)
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT WITH
CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM FACILITIES.
Supplemental Safety and Health

HCC:F3
Boiling Pt:B.P. Text:148 TO 323F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:57.68

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT, SPARKS OR OPEN FLAMES
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED.
Conditions to Avoid Polymerization:EXTREME HEAT, SPARKS OR OPEN FLAMES

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.